Kia Niro: Body (Interior and Exterior) / Troubleshooting

Kia Niro 2017 (DE HEV) Service Manual / Body (Interior and Exterior) / Troubleshooting

Troubleshooting
Symptom
Suspected Area
Remedy
Water leaks from panorama sunroof
Deteriorated roof lid weatherstrip
Replace
Excessive roof lid-to-body clearance and improperly fitted weatherstrip
Adjust
Wind noise around panorama sunroof 
Loose or deformed deflector, gaps in body work
Retighten adjust or replace
Noise heard when opening/closing panorama sunroof
Foreign particles lodged in guide rail
Check drive cable and guide rails for foreign particles
Loose guide rails and lid
Retighten
Motor runs but sunroof does not move or moves only partially
Foreign particles lodged in guide rail
Adjust or replace
Incorrect engagement of motor pinion with drive cable
Decrease in motor's clutch slipping force
Increased sunroof sliding resistance or interference of sunroof with drive cables, weatherstrip, etc. due tomal adjustment of sunroof
Noise in motor (clutch slipping noise from motor when sunroof is fully opened or closed) is considered as normal
Incorrect engagement of motor pinion with drive cable
Check pinion installation and Re-tighten motor
Worn out or damaged motor pinion bearing
Replace motor assembly
Worn out or deformed drive cable
Replace
Door glass fails to operate up and down
Incorrect window glass installation
Adjust position
Damaged or faulty regulator arm or regulator
Correct or replace
Door does not open or close completely
Incorrect door installation
Adjust position
Defective door check assembly
Correct or replace
Door hinge requires grease
Apply grease
Hood does not open or close completely
Striker and latch not properly aligned
Adjust
Incorrectly installed hood
Adjust
Incorrect hood bumper height
Adjust
Water leaks through windshield end rear window
Defective seal
Fill with sealant
Defective flange
Correct

Special service tools
Special Service Tools Tool (Number and name) Illustration Use 09880-4F000 Hog ring clip installer ...

Body Side Molding
...

Other information:

Kia Niro (DE HEV) Owners Manual: USB charger
The USB charger is designed to recharge batteries of small size electrical devices using a USB cable.The electrical devices can be recharged when the Engine Start/Stop button is in ACC/ON/START position. The battery charging state may be monitored on the electrical device. Disconnect the USB ...

Kia Niro 2017 (DE HEV) Service Manual: Pre-Charge Relay Description and operation
Description Built into the Power Relay Assembly (PRA), the Pre-Charge Relay starts to charge the capacitor of the inverter soon after ignition "ON", then it goes out when the capacitor has been fully charged. 1. High Voltage Power Terminal (-) 2. Hig ...

© 2016-2025 www.kniro.net